ProSoundWeb Community

Please login or register.

Login with username, password and session length
Advanced search  

Pages: 1 [2] 3  All   Go Down

Author Topic: Rechargeable AA batteries for UHF wireless mics?  (Read 59460 times)

Christy L Manoppo (okky)

  • Full Member
  • ***
  • Offline Offline
  • Posts: 122
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #10 on: July 19, 2010, 11:35:19 PM »

Darin Brunet

There is no need to completely deplete an NiMH battery before recharging. NiMH batteries do not have the "memory" that older NiCD batteries did.

From Energizer: Battery "memory" is a loss of battery capacity due to partially discharging and recharging repetitively without the benefit of a full discharge. This was evident with early nickel cadmium (NiCd) rechargeable batteries and is not found in nickel metal hydride batteries (NiMH) currently manufactured.


I continually charge and recharge the NiMH batteries in my DSLR cameras, cell phones, AA & AAA's and have never had a problem.
~DB


Yes. Thanks Darin for pointing that  out. But this is just a matter of habit of mine.

The only problem we encounter when using rechargeables is, they have a steeper voltage loss curve when they already spent all their "energy". Unlike alkalines, which seems to have a broader curve.
cmiiw
Logged
Christy L Manoppo
Coordinator for AVL Dept,
Bethany Indonesian Church of GOD,
Philadelphia, PA

Perfect? we can't. Excellent? We can.

Darin Brunet

  • Newbie
  • *
  • Offline Offline
  • Posts: 29
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #11 on: July 20, 2010, 06:07:04 PM »

Arnold B. Krueger wrote on Mon, 19 July 2010 06:10

Darin Brunet wrote on Mon, 19 July 2010 03:43

 BTW, since I remote mount my receivers, the transmitters only go for about 15-20 ft. YMMV.


I was forced to do that with our previous Samson UHF diversity system. They all became illegal, and we replaced them with Shure SLX and AT 3000-based systems.

Remote mounting receivers is pretty nasty because you lose so much feedback about how the link is running. It eliminates the benefits of remote battery status indicators.

In retrospect, the lack of frequency agility was the probable cause of the range related problems that we had with the Samsons. Of course both of the new systems are frequency agile.

I've been able to simulate the same symptoms we had with the Samsons by picking the wrong frequencies with the new ATs. The Shures are self-setting, and never seem to put themselves onto troublesome frequencies.

Getting back to batteries, we've never risked rechargables. The improved battery life with the new equipment, and the switch to AAs is a tremendous benefit.



With the short distance, I have never had any link problems. Also, the receivers I have do not have remote battery indicators, so no problem there, I routinely replace batteries on a schedule. I am using Shure wireless mics and body packs and have never had any issues of any sort with frequency problems. I remote mount my receivers and amps to limit the distance and obstacles the transmitters face and simply run balanced line back to my board. Remote mounting my amps makes for shorter speaker wire runs. They are out of the way and cannot be easily adjusted by novices/volunteers. They are fan cooled and have air filtration around them. Again, just balanced lines from the desk to the amps. My gain structure is such that I do not have issues with amp clipping. At the levels I run the PA, distortion and clipping are never present. This is just how I set things up, perhaps others do it differently but it suits me fine.
Logged
"Serve God first, everything else falls into place"

Darin Brunet

  • Newbie
  • *
  • Offline Offline
  • Posts: 29
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #12 on: July 20, 2010, 06:16:14 PM »

Christy L  Manoppo (okky) wrote on Mon, 19 July 2010 23:35

Darin Brunet

There is no need to completely deplete an NiMH battery before recharging. NiMH batteries do not have the "memory" that older NiCD batteries did.

From Energizer: Battery "memory" is a loss of battery capacity due to partially discharging and recharging repetitively without the benefit of a full discharge. This was evident with early nickel cadmium (NiCd) rechargeable batteries and is not found in nickel metal hydride batteries (NiMH) currently manufactured.


I continually charge and recharge the NiMH batteries in my DSLR cameras, cell phones, AA & AAA's and have never had a problem.
~DB


Yes. Thanks Darin for pointing that  out. But this is just a matter of habit of mine.

The only problem we encounter when using rechargeables is, they have a steeper voltage loss curve when they already spent all their "energy". Unlike alkalines, which seems to have a broader curve.
cmiiw


Christy, with due diligence, I regularly recharge all of the batteries we use in our wireless products. I have never had any issues. AA's should last for more hours of usage than you are actually requiring of them. The only reason I would choose to use 1.5V alkaline type is if the unit specifically requires 3V and will not operate reliably on 2.4V. I choose to use Energizer 2500mAh 1.2V NiMH AA batteries.
Logged
"Serve God first, everything else falls into place"

Shawn_Lockwood

  • Newbie
  • *
  • Offline Offline
  • Posts: 4
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #13 on: July 29, 2010, 10:25:54 PM »

Some interesting discussion here on this topic.  I'd like to share my experience with the rechargeables vs. alkaline battery usage.  My comments are based on several thousand batteries of use at a community college using both rechargeables and alkalines.  

First - if it's a critical situation where you have to depend upon the mic working - use alkaline.  If it's OK to stop what's going on and replace batteries or swap mics then rechargeables are fine.  I make this statement based on the results that I have observed (over a 16 year period) and the related data provided by independent testers as well as that by that provided by Energizer on their web site.  I compared Energizer's info with various tests and charts found on line and they mirror each other.  No...I'm not associated with Energizer in any way.  Second - use Energize or Duracel Pro's for your batteries.  Oh, by the way, there isn't any difference between Energizer consumer batteries and the "Industrial" version.  Both are the same E91 (industrial is labeled as EN91) battery for the AA's and likewise for their 9 volt versions.  The labeling is different and you get a protective cap on the 9 volt version's terminals for the industrial version but that's it (AA's don't have a need for the protective caps).

What is my firm belief in using alkalines during a critical situation based on?  Look at the charts, Engergizer's or anyone else's and you will see the difference between the rechargeables and the alkaline in the area on the chart where the battery is beginning to lose it's ability to provide usable power.  The rechargeable will have a drop that falls of dramatically and with little to no time for use beyond that drop off point.  Alkaline's are much more forgiving with a  gentler drop off and the assurance that it will last for a while longer (my experience shows that it will be around 30 minutes of use or maybe a little less).  I get a solid 8 hours out of two AA's in my belt pack transmitters (Audio-Technica 3000 series mics with a current draw of around 180 ma/hr) with the same for the 7000x series 9 volt versions.  I have gotten upwards of 10 hours or a little more but I never push things that far when it's not just practice.  I do battery checks prior to each use and know exactly how long I can expect a battery to last.  Additionally, you will find that rechargeables lose upwards of 4% per day of charge if left off of a charger/installed in a mic.  As long as you stay within the shelf life of the alkalines you won't have to worry about it's capacity/ability to perform as desired.  

Rechargeables are only good for so many cycles.  I've found that the "1000's" of cycles advertised has never held up for any rechargeable I've every used.  You can not predict with any certainty when a rechargeable will fail to adequately hold a charge.  All of the chargers I've used do not reliably indicate what the true status of the battery's final charge is except in the case of a bad/depleted battery.  Measuring the after-charge voltage can be an indicator but still doesn't tell you a lot about a battery.  I've had rechargeable batteries that measured a solid 1.4 volts or close to it that didn't hack it under load in a transmitter for anywhere close to the amount of time it should have.

All this being said - am I disputing the experience others have had with rechargeables?  Absolutely not!  If you've had a good experience with them and they work in your situation, then take advantage of the cost benefit.  If you've ever had the special for service ruined because the mic died or had the pastor's sermon sputter in mid-message due to bad batteries then you'll know why I promote alkaline use.  I've never had a mic that has had a pre-show battery check die on me mid-show.  I do shows at my college where I can't afford to have a mic die because of batteries.  However, I don't have a problem with stretching out a battery's life for non-critical situations.

I haven't found any (affordable) batteries that beat Engergizers or Duracell Pros (don't use the standard Duracells because they simply don't measure up).  Buying batteries in bulk knocks the cost down to a very affordable amount when compared to buying them off the shelf at Wally-World.

I hope my experience with the above will help with the use of rechargeables/alkaline batteries.  I sure wish that rechargeables were reliable and long-lasting.  It would help my budget a lot.  
Logged

George S Dougherty

  • Sr. Member
  • ****
  • Offline Offline
  • Posts: 317
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #14 on: July 30, 2010, 11:32:29 AM »

Shawn Lockwood wrote on Thu, 29 July 2010 20:25


I hope my experience with the above will help with the use of rechargeables/alkaline batteries.  I sure wish that rechargeables were reliable and long-lasting.  It would help my budget a lot.  


There's nothing in your response that says they can't be reliable and relatively long lasting.

I will say, if you're using 9V, it seems too much of a hassle to me as the 9V rechargeable must be slow charged due to the multiple small cells within the battery.  Attempting to fast charge them like the 15-minute AA's would only cause them to explode.  At that point you'd always be dealing with a slightly older charge on the battery and if you don't have multiples that stay charged, forgetting to charge a battery beforehand means you're SOL.  In my experience, managing the charge on multiple sets of batteries for multiple units and ensuring a proper rotation is eventually an exercise in futility unless your ministry is staffed entirely by anal retentives or one person goes to the extra effort to manage it themself.

Most of the newer chargers are AA only and intelligently turn themselves off so as not to overcharge the battery.  That's a required feature in dealing with rechargeables.  As you noted, 1000's of charges is unrealistic.  100 charges for the high speed chargers is very realistic.  The # of charge cycles actually drops the faster you charge them, but they become much more convenient to use.   For a typical church with one to two services a week, one year's worth of use and then planning for replacement should provide reliable use, reduced waste and some decent cost savings.  At ~$12/4AA assuming even 50 charges or ~1 year of weekly use gets you a cost of about 6 cents per battery, per charge.  Alkaline batteries look to be in the $.30-.40 range in bulk and for reliability I still replaced them every week after 4-5 hours of use.

Everything you mentioned as a reason not to use rechargeables would be directly caused by using them for too many charge cycles based on the speed of charging and improper charging practices.

Charging them just prior to a service guarantees a fresh charge and puts control back with the current operator rather than depending on someone else to have properly done their job many hours beforehand.
Logged

Brian Ehlers

  • Full Member
  • ***
  • Offline Offline
  • Posts: 245
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #15 on: July 30, 2010, 01:37:22 PM »

Building on what Shawn said:

1/  The voltage vs. energy curve of rechargeables makes them inherently very difficult to predict how much longer they will last before needing a recharge.  It doesn't matter if it's the battery indicator circuit inside your wireless transmitter or a human holding a volt meter.  With rechrageables you get less warning of "the end," and the accuracy of your prediction of when the end will occur is less than with alkalines.

2/  As they age, rechargeables hold less energy and their discharge curve becomes even less predictable.  Their constant use and handling also makes them more likely to develop a mechanical failure (short or open).  For these reasons, it is prudent to replace rechargeables BEFORE they become a problem, just as you do for alkalines.

There's nothing wrong with using rechargeables if they fit your needs.  Just don't kid yourself into thinking they are equal in performance and reliability to alkalines.

For me, the hassle of removing and recharging them all the time (and the risk that the last guy forgot to recharge them) rules them out.  My church uses 2 - 5 wireless mics per service, I throw away (dispose of properly) the alkalines well before they're drained, and still we use only about $50 worth a year.
Logged
    -- Brian

Kent Thompson

  • Sr. Member
  • ****
  • Offline Offline
  • Posts: 439
    • http://www.kentssongs.com
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #16 on: July 31, 2010, 02:05:20 PM »

Most of the problems people have with rechargables come from unreasonable expectations.

Do they last as long maybe not. So do not expect them to go through as many services. Have a rotation stock on hand so that you always have fresh batteries available to use.

Make sure that they are properly charged with a proper charger that shuts off when they have a full charge.

As Brian stated make sure you replace them when they start aging.
Logged

Mike Jaspers

  • Newbie
  • *
  • Offline Offline
  • Posts: 5
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #17 on: August 17, 2010, 12:54:10 PM »

I want to address the rechargeable battery debate here.  Our church started to use rechargeable AA and 9v batteries after the economy tanked to save money on batteries.  Also, it has been said that rechargeables are a lot easier on the environment.

We use the Maha Powerex 2700mAh AAs and the iPower US 500mAh 9 volt.  

I use(d) the 9v batteries in PSM 700r(now updated to Sennheiser) product as well as ULXP product.  I have not had a battery die on me yet.  I replace my batteries roughly after 2 uses (6-8 hours, depending), alkaline or rechargeable.  The cheapest I was able to find good alkalines was about $1; the iPower batteries are $18/ea.  So, they make up their value after about 20 charges.  Charge time is usually under an hour.

The Powerex are in use for Shure UHF-R transmitters and Sennheiser g3 receivers.  Freshly charged, they last at least as long as the Procell or Energizer product.  No failures as of yet, either.  I bought some extra batteries so that I could cycle through the product and have enough spare in case I did not have enough time between charges.  I always slow charge the batteries and it takes anywhere from 1.5-4 hours.  Not including the charger, they make up for their cost after 11 uses.  

I still use alkaline AA in our UR1 bodypacks, but only because the pack does not latch well when using the rechargeables.  Since I change the batteries every time for our Pastor, I am able to use old alkalines in other bodypack situations (baptistry, etc.).  

We saved about $1000 this year using rechargeable batteries.  Hope that helps.

Sincerely,
Michael D. Jaspers
Director of Technical Services
First Baptist Church of Springdale
Logged

Paul Wilson

  • Newbie
  • *
  • Offline Offline
  • Posts: 7
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #18 on: August 17, 2010, 11:51:05 PM »

We use some rechargeable batteries and some regular batteries. Obviously the regular ones hold a charge for longer, but knowing when to change them is exactly the same. For me, when the mic gets below full/three bars/whatever battery indicator you have its time to change them.

The fact is once they get below three bars, for instance, they tend to die faster. For example...it might take three hours of use for the mic to go from three bars to two bars and only one hour more for the batteries to completely die. So keep that in mind.

The other thing to realize is that rechargeable batteries still need to be replaced from time to time. It is NOT once you have them you are set for life. Just like a laptop that can't hold a charge after so long a time such is the case with any rechargeable batteries....eventually they need to be changed.
Logged

JAOgann

  • Newbie
  • *
  • Offline Offline
  • Posts: 36
Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #19 on: February 28, 2011, 09:26:49 AM »

Thanks to all of you who commented. Some excellent info.  Jim O Very Happy
Logged

ProSoundWeb Community

Re: Rechargeable AA batteries for UHF wireless mics?
« Reply #19 on: February 28, 2011, 09:26:49 AM »


Pages: 1 [2] 3  All   Go Up
 



Site Hosted By Ashdown Technologies, Inc.

Page created in 0.029 seconds with 21 queries.